Go Back   Ducati Forum > Ducati Panigale Forum > Ducati 1199

Ducati 1199 Ducati 1199 Forum - Ducati 1199 Panigale Superbike Motorcycle Forum


Thanks Tree18Thanks
Reply
 
LinkBack Thread Tools Display Modes
Old Sep 28th 2015, 11:38 AM   #1
Senior Member
 
Joined: Jan 2014
From: United Kingdom

Posts: 359
Thanks: 110

I Ride: 749 , 06 red frame, Scrambler Icon in red, 1199 Panigale abs, 1299SL
MAP sensor problem sloved

Previous thread of mine asking questions and info about the MAP sensor.
Diagnostic test showed vertical sensor failed, I checked with a multi meter and sure enough dead short on the vertical MAP sensor, to test> three wires, earth, 5 volts in and signal out, if 5 volts out of the signal wire then dead short, failed sensor.
I think it was caused by a back fire on start up with my new slip ons fitted, I am sure the back fire blew out the MAP sensor as its only a silicon membrane inside, note the exhaust valve was disconnected and maybe did not help.
Research found a Diaval site thread that answered my questions, why was my bike running OK when the ECU light was on and engine warning lamp lit up.
Diavel thread goes like this so I guess Pani the same, 2 sensors, one for each cylinder, when one fails the reading comes off the good other sensor, if both fail then there is a parameter set so the bike will run. After 20% of throttle it does not use the MAP signal only throttle and speed sensing, so hence did not notice a running problem, though it did stall on me once.
I bought a sensor when I got back in the UK, left side electric box both are located, wiring is labeled vertical/horizontal, just connected the new sensor to test and ECU warning lamp gone.
Now the cheating bit, no need to remove the tank, get a 5mm allen key socket bit, drop it into the bolt that holds the sensor, undo with a spanner, the nut is captive in the plastic, unclip the hose, reuse the clip, fit new MAP sensor, run bike. This will save you a load of cash as the dealer will remove the tank etc.
If anyone needs more info drop a line, check pictures to make sense of the above babble!
Also the dealer said they sold a few lately but mainly for the 899.
Attached Thumbnails
MAP sensor problem sloved-2015-09-26-15.29.30.jpg   MAP sensor problem sloved-2015-09-26-15.29.20.jpg   MAP sensor problem sloved-2015-09-26-15.33.31.jpg   MAP sensor problem sloved-2015-09-26-15.40.43.jpg  
Thanks from AntiHero, Stu, xpercad and 6 others
farmind is offline  
 
Old Sep 28th 2015, 12:50 PM   #2
Senior Member
 
Gecko's Avatar
 
Joined: Sep 2012
From: Switzerland

Posts: 1,799
Thanks: 1701

I Ride: 1199 SL, 1199S Tri, 1299S Anni, MV Agusta F4 750, M1200S, M696, Husaberg FS650e, Petronas FP1
Very nice trick with the wrench!
And many thanks for this valuable information.
Thanks from farmind
Gecko is offline  
Old Sep 30th 2015, 03:12 PM   #3
Junior Member
 
Joined: Oct 2013
From: USA

Posts: 9
Thanks: 0

I Ride: 1199 S
Same here!

Nice trick with the wrench; just be careful not to strip anything with that much leverage.

Thanks!
DesmoDuck1199S is offline  
Old Jun 10th 2016, 01:58 PM   #4
Member
 
Joined: Mar 2012
From: Glasgow, Ky, USA

Posts: 39
Thanks: 5

I Ride: 2012 1199 Panigale
Quick question. How much for the Map sensor?
duc1199ky is offline  
Old Jun 18th 2016, 10:57 AM   #5
Senior Member
 
Joined: Jan 2014
From: United Kingdom

Posts: 359
Thanks: 110

I Ride: 749 , 06 red frame, Scrambler Icon in red, 1199 Panigale abs, 1299SL
Originally Posted by duc1199ky View Post
Quick question. How much for the Map sensor?
Check ebay.co.uk but without digging the reciept out think it was 80, 130 $ ish.
I read your thread, by the time they test, rip the bike to bits it costs but 700 was too much, if both were gone with removing the tank the most it would have took would be hour and half, as you see I cheated and took half hour.
farmind is offline  
Old Jun 18th 2016, 12:49 PM   #6
Member
 
Joined: Mar 2012
From: Glasgow, Ky, USA

Posts: 39
Thanks: 5

I Ride: 2012 1199 Panigale
I ordered 2 map sensors today and going to do the work myself. There's no way I'm going to pay that much to fix it when I can do the work myself. When you replaced the sensors did the engine light go off or did you have to have it reset?
duc1199ky is offline  
Old Jun 19th 2016, 12:10 AM   #7
Senior Member
 
AntiHero's Avatar
 
Joined: Nov 2011
From: Round the World on an 1199

Posts: 2,084
Thanks: 2247

Shorty allen key set will do the trick, too.
Thanks from duc1199ky
AntiHero is offline  
Old Jun 20th 2016, 09:54 AM   #8
Senior Member
 
Joined: Jan 2014
From: United Kingdom

Posts: 359
Thanks: 110

I Ride: 749 , 06 red frame, Scrambler Icon in red, 1199 Panigale abs, 1299SL
the engine light went out after I fitted the new MAP sensor.
Thanks from duc1199ky
farmind is offline  
Old Jun 24th 2016, 08:35 PM   #9
Member
 
Joined: Mar 2012
From: Glasgow, Ky, USA

Posts: 39
Thanks: 5

I Ride: 2012 1199 Panigale
Replaced both map sensors today. Light is gone and the bike is running like new again!!
Thanks from Marmoot and farmind
duc1199ky is offline  
Old Jun 25th 2016, 05:51 AM   #10
Senior Member
 
Joined: Jan 2014
From: United Kingdom

Posts: 359
Thanks: 110

I Ride: 749 , 06 red frame, Scrambler Icon in red, 1199 Panigale abs, 1299SL
Originally Posted by duc1199ky View Post
Replaced both map sensors today. Light is gone and the bike is running like new again!!
I am happy it worked out, lot of people help me on this forum.
So the final cost? and time it took, I take it you did it yourself?
farmind is offline  
Reply

  Ducati Forum > Ducati Panigale Forum > Ducati 1199

Tags
map, problem, sensor, sloved



Search tags for this page
Click on a term to search for related topics.
Thread Tools
Display Modes


Similar Discussions
Thread Thread Starter Forum Replies Last Post
MAP sensor farmind Ducati 1199 2 Sep 7th 2015 11:36 PM
Want To Buy: 02 sensor Tyler1199 Want To Buy 2 Sep 2nd 2015 07:25 AM
Want To Buy: GPS sensor DynastySS Want To Buy 4 Mar 26th 2015 08:28 AM
Sensor Posizione Cambio / Gearbox Position Sensor Solida KSB Mechanical and Technical 4 Nov 29th 2013 09:41 PM
Gear sensor Faisal Mechanical and Technical 3 Aug 6th 2012 04:14 AM


Facebook Twitter Google+ RSS Feed