Go Back   Ducati Forum > Ducati Panigale Forum > Mechanical and Technical

Mechanical and Technical Mechanical and technical topics, help, and discussions

Thanks Tree9Thanks
  • 4 Post By able duc
  • 1 Post By 0612Devil
  • 1 Post By 0612Devil
  • 2 Post By royal
  • 1 Post By Phl
LinkBack Thread Tools Display Modes
Old May 1st 2018, 01:01 AM   #1
Khmer1199's Avatar
Joined: Sep 2015
From: Siem Reap, Cambodia

Posts: 63
Thanks: 42

I Ride: 1199 Panigale
Troubleshooting Guide

Who hasn't experienced a problem with their bike? There's a lot of experience on this forum as well as others... and a lot of information to be shared. I'd like to compile as much data as possible and put together a troubleshooting guide that everyone might benefit from. It'll be kept fairly simple and include the following fields:

1. Year/Model- the year and model of your bike
2. Symptom- very short description of your problem (example-does not start)
3. EOBD- is your engine light on?
4. Error Message- is there an error message present on the dash?
5. DTC- if diagnostic software was used to diagnose the fault, what code/message was reported?
6. Cause of Failure- what caused the failure? (example-bad battery)
7. Corrective Action- what actions did you take to correct the failure? (example-replaced battery)
8. Special Notes- add only if necessary, and if necessary, be brief

Only contribute if you're absolutely positive that a given corrective measure resolved the fault that you experienced. Don't say your bike was running rough and you replaced three different items and now the bike runs great. You don't know precisely what corrected the problem.
Khmer1199 is offline  
Old May 1st 2018, 02:14 AM   #2
Senior Member
able duc's Avatar
Joined: Nov 2016
From: Mid Nth Coast NSW

Posts: 1,008
Thanks: 356

I Ride: 1199 - - - - - - - - - R1200GS Rallye X - - - - - Sherco 300SEF-R - - - - -
1. 2013 1199 base
2. Very hot while riding naked
3. No engine light
4. No error
5. No diagnostic used
6. Nuts were touching the subrame bolts (nuts and bolts)
7. Put some trousers on to stop the freeballing
8. Seems to be much better with trousers on, am thinking of wrapping my sack in titanium material wrap for the next nude ride. I would have posted images of the bag in question but have trouble uploading images.
Thanks from Phl, cmh210, royal and 1 others
able duc is offline  
Old May 1st 2018, 06:35 AM   #3
Senior Member
Joined: Apr 2014
From: New York, NY

Posts: 396
Thanks: 165

I Ride: 2011 Monster 796 & 2013 1199 Base
1. 2013 1199 Base
2. Oil collecting on and below clutch cover and belly pan.
3. None
4. None
5. N/A
6. Horizontal and vertical valve covers leaking.
7. Pulled valve covers, cleaned mating surfaces, liberally applied ThreeBond gasket sealant, re-torqued the valve cover bolts. Has not leaked since.
8. N/A
Thanks from Khmer1199
0612Devil is offline  
Old May 1st 2018, 06:38 AM   #4
Senior Member
Joined: Apr 2014
From: New York, NY

Posts: 396
Thanks: 165

I Ride: 2011 Monster 796 & 2013 1199 Base
1. 2013 1199 Base
2. Found coolant pooled underneath bike the morning after a ride.
3. No
4. No
5. N/A
6. Leaking thermostat/squirter unit.
7. TBD - Found leak at seam of two piece thermostat/squirter. Pulled thermostat, cleaned and applied gasket sealant, pending reinstall. Will replace thermostat unit if still leaking.
8. None.
Thanks from Khmer1199
0612Devil is offline  
Old May 1st 2018, 09:42 AM   #5
Senior Member
royal's Avatar
Joined: May 2014
From: London, UK

Posts: 497
Thanks: 352

I Ride: 2016 1199R Pani, R6 racer, 2014 1199S Pani, 2016 BMW S1000RR, KTM 250exc, GasGas 250txt, skateboard
1. 2015 1199R
2. Wheelies like a beasty
3. EOBD- no
4. Error Message- no
5. DTC- Traction control sorcery turned off
6. Cause of Failure- Throttle hand of god
7. Corrective Action- Held at the balance point
8. Special Notes- Was a hero
Thanks from Phl and able duc
royal is offline  
Old May 1st 2018, 11:52 AM   #6
Phl's Avatar
Joined: Feb 2012
From: here

Posts: 7,517
Thanks: 4090

I Ride: Panigale, CRF450, CRF50, GROM, bionicon supershuttle
1. 2012 1199 base
2. got a speeding ticket
3. no
4. no
5. ask the officer
6. went too fast, still felt slow
7. paid an attorney and bought a radar detector
8. won the case for improper equipment and never got busted since
Thanks from able duc
Phl is offline  

  Ducati Forum > Ducati Panigale Forum > Mechanical and Technical

guide, troubleshooting

Thread Tools
Display Modes

Similar Discussions
Thread Thread Starter Forum Replies Last Post
Tyre wear guide wilkson Mechanical and Technical 0 Oct 25th 2016 02:39 AM
Please point me too a S electronic suspension guide tjprattctr01 Ducati 1199 15 May 24th 2015 11:20 AM
Throttle Problems -- Troubleshooting Help Needed dujuruprincipe808 Mechanical and Technical 11 Dec 18th 2014 09:08 AM
Guide to Change Rear Sprocket - Please Xbox Mechanical and Technical 12 Mar 26th 2013 09:52 AM
Help with How to Guide gman74 Mechanical and Technical 1 Jan 7th 2013 09:06 PM

Facebook Twitter Google+ RSS Feed